Front and rear drive shaft for my car

Replace a Spare part Drive shaft – a defective one or if the limit of use has been already reached. Find out useful information about Drive shaft

Malfunction of the drive shaft

• mechanical damage or deformation of the drive shaft;
• wear of halfshafts;
• damage or wear and tear of the drive shaft joints;
• damage to the drive shaft bearings.

Symptoms of the drive shaft faults

• vibration under the bottom while driving;
• roll to one side;
• pulling to one side when driving straight;
• wheel tramp;
• leakage or foaming of transmission fluid;
• problems with gear shifting;
• slipping during gear changes;
• noise under the bottom;
• oil leaks under the car during periods of inactivity.

Causes of the drive shaft malfunctions

• overloading the vehicle;
• use of low-quality lubricants;
• too abrupt starting and braking of the car;
• looseness of halfshafts mountings;
• ingress of dirt or foreign objects into the system;
• clogging or damage to the gaskets and seals;
• failure to comply with the vehicle operation rules;
• a gap between the hinge and the core shaft;
• aggressive driving style or systematic driving off road;
• defects and faults of closing rings.

Diagnostic

Checking the drive shaft status is a complicated task and is carried out in several steps. First, run a control test drive at low speeds (20-30 km/h). It is necessary to make several sharp turns in both directions. Abnormal sounds when cornering is one of the main signs of malfunction.

It is also possible to independently evaluate the structural condition of the shaft, its pollution and damage. In addition, you should also examine the seals, dust caps and clamps. Further diagnosis is necessary to be carried out at a service station. In case of excessive pollution it is required to clean the shaft and all the transmission system elements.

The drive shaft is part of the transmission, so its diagnosis is carried out only together with the other elements of the system. Complete diagnosis of the car suspension at a service station should be carried out every 15,000 kilometers.

Repair and replacement of the drive shaft

The drive shaft consists of a number of components, so at failure it is sufficient to replace only the parts that fail. Identifing the faulty part of the drive shaft independently without any special knowledge and tools is almost impossible, so the repair and replacement of parts is carried out in a workshop.

Complete replacement of the drive shaft is held at strong damage during accidents or excessive wear of the entire system.

Helpful tips on operation, causes of faults, troubleshooting, and service intervals

• What does a drive shaft do and what are the symptoms of malfunction?